Update from Apr 24, 2015: I want this moved to computer_PCM_failure (91 complaints) instead of in the engine section. The batt light goes on and the entire instrument cluster (spedo fuel turbo temp etc ) shuts off .. when it's off the climate control won't work and the sun roof won't work . He was on the right, so I moved around the car to the right looking towards the engine. Suppose I was going 60mph, I would have lost control of the vehicle. I had no warning, no lights had been coming on. I had no where to turn off, no power steering, and very little braking power. But on a hot day (90+) when moving from a stopped position out of a parking spot or around a corner, when you lightly have the brake pedal depressed if you turn the wheel slightly (ie backing out of a tight parking space) the car will lunge violently and aggressively in what ever direction you are traveling, sometimes so aggressively it will stall the vehicle out and then go into a failsafe mode. if I do not have foot on gas on break it will continue to move. updated 05/23/11. 2005 FORD Five Hundred Subscribe to alerts for a 2005 FORD Five Hundred Submit a complaint about a 2005 FORD Five Hundred These recalls apply to the make, model, and year of your car - and should be fixed as soon as possible. After spending 2,400.00 Dollars, that I had to borrow, the car is still not running right. Members can start their own topics & subscribe to topics The manufacturer was not notified of the failure. Thanks for listening. The vehicle will stall and jerk. to no avail. Out of Fuel. Go to another state & leave it there. Since I have been reading up on the issue I noticed that there was a letter sent out to owners of my model which I did not receive. Along with the first completely new full-size chassis since 1979, the 2005 Five Hundred introduced two distinct full-size model lines to Ford (for the first time since the 1978 discontinuation of the Custom 500). Instrument panel shuts off intermittently. I was 80 miles from home when the engine shut off. Pulled in drop off a donation at a second hand store. It will surge making slow turns and surge when put into drive. statistics and reliability analysis of Ford Five Hundred based on all problems reported for the Five Hundred. 5 screws if I remember correctly. Ask your Ford dealer. Five Hundred Instrument Cluster Goes On and Off | Ford Forums Towed it to the dealer and the dealer spent over 6 hours to come to the conclusion that throttle body needed to be cleaned and pcm reprogrammed/updated. The manufacturer was not made aware of the issue. NOT ACCEPTABLE FORD and my wife and I will not be giving you ANY business in the future as my 4th Ford product in 15 years will now be something other than a Ford with 100K and a 10 year warranty from a competitor. . I am typically not one to complain, but I feel very strongly about the safety of this vehicle, especially since I have a 3yr old daughter. Prior to replacing the Harmonic Balancer at 50K (Approximately $500.00) the vehicle had behaved the same way, randomly turning off while driving. ". Glad it's being fixed. The contact stated that the instrument cluster dimmed intermittently which made it difficult to see the display. Shutting off while driving! There are hundreds other complaints. The problem might be with a defective crankshaft position sensor. The contact owns a 2006 Ford Five hundred. Would not start, had towed to mechanic. Cluster panel just shuts off while running and can't use air, radio, windows, locks, seats, etc. Can I Just Install A Fuel Pump Outside The Tank? Engine Shutdown While Driving 2005 Ford Escape (Page 1 of 2) This problem may be covered under warranty. After doing an online review I noticed that many other Ford Five Hundred owners having the same issue and seems to be caused by "throttle body". The contact stated that at times when the vehicle was stopped at a traffic light, it would accelerate slowly upon take-off. I just bought the vehicle 6 days prior to the problem. Total repair cost $2,700. 05 500 Limited, AWD, CVT Amp and 2, 12 inch boomers in the trunk. I am having this repaired at the moment. To restart, must shut car off, key out and it will restart. 6.0 randomly shuts off - Ford Truck Enthusiasts Forums Till car stops, but it restarts when plugged back in without turning car off or removing key - therefore it must be a different failure. In addition, the vehicle would suddenly stall and the fail safe engine sensor indicator illuminated on several occasions. This is dangerous; unable to tell speed! also, check the battery. Sometimes the abs light comes on before it shuts off. A few times it worked for short periods of time. at idle, it went away and everything was fine. The manufacturer was not made aware of the failure. problems related to electrical system (under the electrical system category). Thanks for the update. The VIN was unavailable. So the first thing I did was open the hood and make sure nothing was on fire. So now I'm still paying the loan on it while it sits in shop waiting for the part. The vehicle was taken to an independent mechanic for diagnosis where the vacuum operative valve behind the throttle body was replaced. I managed to get it to my mechanic. The vehicle was taken to a local mechanic who lubricated a component (the contact was unsure of what component) but the failure continued. The mechanic stated that the transmission needed top be replaced. The rpm's were low and it would idle rough and surge from low to high, I tried hitting the gas pedal and the car stalled! Of course the coverage ended on 03/31/2013. I have also had an idling problem. I had to pull over and shut the car off. I am writing Ford Motor Company to voice my concern but doubt it does any good. The failure mileage was 75,000 and the current mileage was 134,000. I am worried that my car will give out again like this resulting in an accident. Do Not Sell or Share My Personal Information, 2006 F150 5.4 Sputtering - New thread CONDENSED, https://www.morepowertuning.com/how-to-idle-relearn. The failure mileage was 68,780. It's only right that Ford take care of their customer since this is a common problem and a big mistake on its part. Pulled over and shut car off and restarted it again a few minutes later and everything was fine. Jun 6, 2012. If you are in drive and put it into park the rpm will also surge as high as 2500. Car will be driveing 55 and completely shut off. At the very least, get a hold of a diagnostic scanner, plug it into the OBD-II connector (located under the dash to the left of the steering column), and get any codes that are stored. Have replaced all parts suggested by codes. The contact coasted the vehicle to the side of the road, turned it off and restarted it. I coasted to a stop and restarted the car. This is dangerous and should be an electrical recall. I had it towed to the shop and low and behold it is the computer and catalytic converter so far and the mechanic states he hasn't seen anything like this since car is in good shape. I am so glad my baby and kindergartener weren't in the car at this time! Engine shut off while driving - Ford F150 Forum - Community of Ford Ford Five Hundred owners have reported 25 I really feel a class action suit or recall is needed. Had to have it towed. You must be able to get it stopped on the side of the road and shut the car off and then restart it to correct the problem for a short period of time. HELP! The crankshaft position sensor's role is monitoring the engine's many moving parts including the crankshaft, engine valves, and pistons. This fixed the car and have no issues or lights. Ford Focus Shuts Down While Driving (Common Causes) The time yesterday, I was in a residential area, so I was not going that fast. I have half my oil life left. Aftermarket is not to be trusted. I fully suspect a set of wiring and spark plugs will also turn up in this " open checkbook event " just as apparently most everyone else has had for the " FIX " to this NASTY problem with the '05 FORD Escape. The vehicle was taken to the dealer where the contact was awaiting a full diagnosis of the failure. I had this car repaired twice at a professional mechanic shop that cost me thousands of dollars. See After researching the internet, I have come to find that this is a common occurrence with Ford and an announced recall should be implemented immediately. 2005 ford 500 shuts off while driving I have a busted motor mount and transmission mount on a 2005 Ford Five Hundred just as of yesterday here in Memphis it has started to warm up so I had my a/c on yesterday and when in operation while at slow speeds or at stop light the car will idle rough and start shutting on and off for about a millisecond. The contact owns a 2005 Ford Five Hundred ltd. The mechanic drained the air conditioning system however, the failure was not corrected. I was not driving fast < 30 MPH. we love it. Code is p0191, replaced fuel pump and inertia switch as suggested in tsb. Pull the EGR valve and leave it like that overnight. !!! Inside the cover are two large. Cruise does not work. Vehicle then began showing random warning lights including "check engine", which was diagnosed first time as low fuel level sensors a & b. The car was driven from Florida to Philadelphia with no problems and it had its regular inspections. Then instrument panel speedometer goes black, if you got the dash it comes back on the battery got completely drained bought a new one. They basically didn't know what was going on with the exception of first replacing the PCM for $1200 at Fords cost. I can't keep buying and replacing coils on this thing since it's not paid off and in my bankruptcy I can't trade it in either. . Oil was present in the engine and no other major issues seemed to be present before this one. When I Turn The Key I Here It Start And Then It Stalls Out. Now it cuts off while driving and reverse light on while dash is out 0 replies Report Answer Get it fixed today at a shop near you 2005 FORD FIVE HUNDRED 90,000 MILES Car stalls while driving. The vehicle was merged to the shoulder, turned off and then restarted after several minutes, as it resumed normal operation. install it and then test the new PCM. The contact owns a 2005 Ford Five Hundred. The vehicle was taken to a dealer who diagnose that the throttle body sensor needed to be replaced. When stopped at a light for instance the idle speed becomes low and sometimes stalls. The vehicle would then be towed to an authorized dealer where they were always unable to diagnose the failure. after I was happy that it had crunk up an was running again, so I changed it imediately and crank it up and same thing happens again. Just bought a used Escape in August, everything checked out ok. No lights, no dash lights, no radio, no a/c, no wipers and the car was in drive at 40 mph. If mine wasnt on while starting, the truck would idlr high and feel like trans was slipping while depressing gas made the truck nearly die. Recalls need to be put into place before someone dies! Then I wrote them a letter and here is the last line of the letter they sent me " Thank you for contacting Ford Motor Co. We are sorry that we were not able to meet your expectations. It took at least three tries to get the truck restarted. Unsubscribe any time. I was a hundred yards away from my house and the dashboard lit up with all possible warning lights, then the engine died, and refused to turn over. Many people's description of a defective transmission body matches our description, but that part is, apparently, on backorder. This happens at different times of day and seems to be more often when it is warmer. Today, while driving it died. The contact was able to shut off and restart the vehicle in order to operate normally. 10/17 will bring once they get them installed and try starting it one more time. I put it in park and turned off the vehicle; opened the trunk; and looked up startled when a guy sitting nearby said that my car was smoking and on fire (about 10 seconds since I switched the car off and got out). only code that comes up is number 6 injector. The failure recurred five times. The Ford dealership, where I purchased the car, diagnosed the problem. The vehicle was taken to a local mechanic for inspection. While driving the dash board goes dead and all of the gauges go to zero. Said failsafe mode then check engine light illuminated, dash board said check engine check transmission then the light went out the following day. Last time this occurred car required towing to local Ford dealer. The contact stated that while driving 70 mph, the wrench warning indicator illuminated as the vehicle stalled. The contact owns a 2005 Ford Five Hundred. I bought this car in May of 2009. Just driving along at around 45-50 mph and the vehicle just dies and steering locks up. This is dangerous as it almost caused an accident by jerking backward immediately when I shifted to reverse when I was in the parking lot- my foot was on the brake and the car still excelled. Ford House Said The Fuel Pump Was Bad Where Is The Fuel Pump Located In A 2000 Ford Excursion V10. I had a bad no-start situation because the key was only working when inserted just the right way. 2005 Ford Explorer Engine Stalls/Shuts Off While Driving Consumer stated the left front head light caught on fire spontaneously while having been parked for 30 minutes in the garage and engine was off. Speedometer doesn't register, I can't tell when I need gas. The underside of the mirror had caught fire and started burning for a bit before the fuse finally blew. 2005 Ford F150 Starter Fuse LocationFord F-250 / F-350 / F-450 / F-550 Faulty Crankshaft Position Sensor One of the most common reasons for the issue of car shuts off while driving is a faulty crankshaft position sensor. Four coils are bad and it burned the circuit board or whatever you call it. It was a very scary situation. 2005 - 2007 Ford Five Hundred Throttle Body Problems DIY Auto Homeschool 18.7K subscribers Subscribe 1.2K Share 96K views 3 years ago In this video, we are dealing with throttle body issues on. It may be an electrical issue causing your Mustang to shut off, so your Ford dealer will be able to diagnose it. The battery will just die and stop holding a charge. Cost $1800. 2005 ford 500 wrench light, changed throttle body, updated PCM still going limp on me 16 Answers. Worst car ive ever bought second major incident that has happend since I got yhe car. There are times when it happens every day, and there are times when it doesn't happen for a month. All I could think about was to move over into the right lane and get off the road somehow. Instrument cluster intermittently went dark and/or gauges went to zero/off positions, we pulled over to see if exterior lights worked and all did, as well as blinkers and flashers, but we noted that reverse lights were now on. If I wanted the new computer the part alone is 1100.00 and probably would have gone through the coils again. Replaced computer, wiring harness, alternator (because diagnostic report showed problem), 3 coils bad, replaced all 6. I can be doing 10mph n go to turn a corner n it shuts off. Changing the fuse fixed the problem. There was bumper to bumper traffic on a hot day. The fuel pump fuse had a crack in it. Still have a short somewhere . DANGEROUS!!! This is a flaw w Ford 500 2005 throttle body many complaints and test does never issues recall, unsafe. The contact owns a 2005 Ford Five Hundred. Ford its time to step up and do a recall!!!!. HELP. I do not think it should be my responsibility to pay for this since the part was recalled !!! Also, when using cruise control, the whole car shakes and stutters slightly when going up or down very slight inclines. 2022, CarProblemZoo.com All rights reserved. The contact opened the hood and flames emerged from the engine and the smoke turned black. Fuel Pump Problems: Car Stalls While Driving. Code Is P0191, - 2CarPros Every time, the car comes to stop or dies on me. I reported it to Ford, and got a nice complaint number. No wonder there has been one the parking lot where my co-worker picks me up.. w/flat tire for a month. [DROF_3380] 02 Ford Excursion Fuse Diagram Fuse Diagram - OSSIE. Well, I moved houses on the other side of town and had to move it and could not afford a tow so I drove it for about a mile or so and it shut off once at the red light when I had to sit and wait but when it shuts off it will start back up. What was upsetting is that this is a common problem for this year of Escapes. this is on a 2007 Ford 500, low miles. 20258 2003-2008 ELECTRONIC THROTTLE BODIES (ETB)EQUIPPED VEHICLES - HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM . Once the vehicle was restarted, it began to jerk when accelerated. Oil and brake light illuminate constantly. The contact stated that while driving 65 mph the vehicle stalled. The vehicle was not further repaired. The vehicle was not diagnosed or repaired. I always liked Fords, but I don't know now. This has happened about 7 times now. I had my foot on the brake, I was about to stop. Was on a busy interstate doing 70 mph and managed to get the car to the side of road on the shoulder. What Do You Have Any Suggestions To Help Figure Out Why 2005 F150 With 4.2l 6 Cyl 2wd Will Not Start. However, I'm not really surprised about that. The vehicle had not been repaired. It has recurred a few times, its most noticeable after dark as dash lights go black. Since I bought my car in 2007 I am on my 4th battery. No codes for doors. I have also noticed a mechanical smell coming from the ac. The extended warranty company also refused to honor the warranty also. Car shuts off while driving down the road. . You dont have lots of cute thingies on the keychain do you? " Just because the check engine light isnt currently on, does NOT automatically mean there are not stored fault codes to retrieve. I was on freeway and could have been severely injured if I was hit. Ford is being weenies about this when I call they nadethe original spark plugs to be quieter and ended up being the root problem of car. An employee of the store that was on the back, left side of the car pointed towards and said, look! Pmb. finally got it started by holding brake and pushing on accelerator while putting it into drive so that it would not stall out. My next stop was to get two propane tanks filled. CK Engine light came on and started flashing. I am always extremely cautious when there are people around when I slow down to less then 15mph or back up. We don't sell/share your email. I live in spokane washington, but I had to have the battery replaced once while I was on vacation in montana. The car now sits in my driveway where it was towed to and sits for safety reasons. See Also will start bucking and shut off. I was stopped at an intersection. And as long as it is a hot day I can duplicate the results continuously, and would be more than willing to show this to someone else if possible. No lights and not running rough. Initially said it was the throttle senor for a cost of $300. The engine light went full and I lost power completely, with barely enough notice to pull off the highway. Jun 23, 2011. nicholasmor1 said: my new 2011 F550 that only has 4500 miles on it shuts off while driving. The RES control will not work if the CNCL vehicle speed is not faster than 30 mph (48 km/h). The vehicle was not repaired. bumpy road ) its now done it 5 times, Ford looked at it once and drove it for 20 miles, said they couldnt recreate the problem, has anyone experianced anything of . the contribution test injector is firing right. The contact owns a 2005 Ford Five Hundred. Have a 2005 Ford Escape on my out of town car stopped. Drove it for a day and then had the same problem in traffic when at low rpm, with children in car at intersection car stalled out! I was driving on freeway to pick my child from daycare when all the sudden the car stalled out. The failure and current mileage was 138,000. My daughter managed to get car off the road. . Driving Procedure: Release pressure in the fuel tank by removing and re-installing fuel cap. Had the battery reset had no impact on the problems I would say it's a mechanical matter, but it seems clear its a computer or electrical issue. Car shutting off while driving - Mustang6G This happens frequently almost daily in the summer. I then replaced a coil pack. Borrowed a car AGAIN. The Fora platform includes forum software by XenForo. Our harness is an upgraded, direct replacement for the GM 15862656 and the AC Delco PT2195. Limp mode. But the alternate is putting our 14.2 at idle.when this issue happens every accessory shuts down except headlights and the engine. I will never buy another Ford vehicle ever again!!!!!! by tmac1180 Mon Nov 01, 2010 7:14 pm, Post per internet research this is happening in several Ford models and stems from a bad solder joint. Signal lights melted and quit working. . I Was Driving It On The Hwy When The Truck Just Turned Off. PCM ( power control module ) was fried according to service manager after spending a day " diagnosing " and running volt/ohm checks on everything. It should be a recall. Had it towed to the nearest town. We have since talked to several Ford dealers including Ford motor company , they all said it was our responsibility to fix the problem. If it comes on, try to only start the truck while cluster is on. The vehicle was taken to a independent mechanic for diagnosis. FORD FIVE HUNDRED 2005 OWNER'S MANUAL Pdf Download Starts doing this as soon as the car is started. The failure recurred after the repairs. I can't afford repairs or a new car. Then google each code (and/or post them here) to gain additional information as to why the engine is shutting down. Is there anyone else that has had this problem. While driving approximately 70 mph, all of the gauges on the instrument cluster stopped functioning and displayed readings of zero. I was almost sold on Ford until recently when I was with my family in my 2005 Ford Explorer. Very disappointed in car & it being TOTALLY unreliable. I do not think it should be my responsibility to pay for this since the part was recalled !!! It does appear that it only happens when the accelerator is not depressed and will sometimes stay running if you hit the Gas Pedal as soon as it starts to happen. they have put my family at risk more than once and they need to fix this problem before someone gets hurt. and started it again. Reverse lights come on and airbag light comes on. It should be a recall major safety violation. It began with the 12 volt not working. While driving approximately 50 mph, the contact stated that the vehicle stalled. Ok I was driving and it just shut completely down after I found out my ignition coils was going bad and was about to replace it. When I drove it to my mechanic, it did the same thing but began flickering on and off the whole way there. My 2006 Ford Five Hundred is surging there's no power it stumbles shuts off. On a trip south on an interstate, my car overheated. Can seem to run fine, be in the middle of an intersection and the car shut off and wouldnt restar good thing I can drive and knew what to do or I would have crashed numerous times. The most recently reported issues are listed below. I had my Ford 500 3mos, at first all dash board lights would go outand maybe come back on the same day. problems related to car stall (under the engine and engine cooling category). Tl the contact owns a 2005 Ford Five Hundred. At the time no warning lights. all problems of the 2005 Ford Five Hundred So, OPTION A..get a junkyard to cut off the end for $50 and splice/heat shrink on to existing cable. 2. See The failure occurred sporadically when driving at low and high speeds. The manufacturer was made aware of the failure. Then at pharmacy drive thru w car I. You need to get a new cluster and replace the old one. I managed to get the dead metal off the road and into a store parking lot. was told by a mechanic that he cannot diagnose the problem unless . Please watch out if you are next to a Ford 500. Unable to restart. I was not driving fast < 30 MPH. The contact stated that while driving 70 mph, the wrench warning indicator illuminated as the vehicle stalled. They get two codes that come up which they then in turn say that it is the throttle actuator and or the throttle sensor and/or the throttle body that needs replaced. The car will lurch forward, the lights on the dashboard will all light up, and then the engine will shut down causing us to have to shift into neutral and try to pull over to safety. Marcus, the service manager informed me a new wiring harness was now needed since the original one was melted by the PCM shorting out. The failure mileage was 60,000 and the current mileage was 80,000. The vehicle would then stall once the message was displayed and would not restart. Please issue a recall on the instrument panel replacement. I recently bought a 2005 Ford Escape. Get notified about new defects, investigations, recalls & lawsuits for the. That is costing me 1600.00 dollars. Get notified about new defects, investigations, recalls & lawsuits for the. This is probably an easy fix, but if it isn't fixed, much worse could happen!. When I ok'd that repair, the dealership called back later and stated it was the entire throttle body and repair would come at a cost of $1000. It appeared, at first, that this problem had come out of nowhere when I suddenly remembered two occasions when the rpms suddenly stuck on 3000 and would not stop until I put the car in neutral. The approximate failure mileage was 75,000. See Morning after I installed pump, started & shut off again. I bought from original owner, low mileage (they upgraded). I had already replaced 2 coils at 300 a whack. I see someone already pointed out no recall on this problem. I was driving 35mph and all of a sudden my car had no power, I gave it gas and it would growl but no power.

Rockcastle County Property Valuation Administrator, Articles OTHER